Sorting And Bunching

In some local markets asparagus is sold loose, by weight, in which case but little regard is paid to the size and length and color of the stalks, nor to the style of packing. This is the most profitable way for the grower



to sell, as it saves him all the expense and labor of bunching, and as even the smallest stalks are thus salable, there is no waste whatever, while the prices obtained are about the same as those for first-class bunches--that is, two pounds of loose asparagus sell for about the same price as a full-sized bunch. But in city markets asparagus could hardly be sold in such a condition, and it is of first importance that it should be carefully graded and neatly bunched. Sorting.--Careful growers assort into three sizes: extras, primes, and seconds. The size and weight of the bunches vary somewhat in different markets. Bunches varying from six to twelve inches in length are received at wholesale centers, but the most convenient and popular size for a bunch of prime white asparagus is eight and one-half inches long, averaging thirty spears, and weighing two pounds. The side view of one and the end view of three bunches of this size of white asparagus are shown in Fig. 27. To assure uniformity some ingenious contrivances have been invented, most of which are a great improvement over the old-time bunchers, consisting merely of a board with four pins, six inches long, and placed about four inches apart each way, to form a square. Two strings, usually of bast matting, were laid down on the board, which was set on a bench up against the wall, or had a back made of another board tacked on it at right angles. The asparagus was laid on the buncher between the pins, the tops touching the back or wall to keep them even. When the bunch was large enough the strings were tied firmly, and the butt end of the bunch cut square. Bunchers.--The modern bunchers are constructed of cast iron and are easily handled. One of the first to come into use was Conover's (Fig. 28). The principle of the operation is that the stalks are placed between two brass strips, a hinged cover is brought down by means of a lever and held in place until the strings are tied. Two ties should be used, one placed about two inches from either end. The bunch must be tied so tightly that it will not loosen in handling and transportation to market. The Watt's Buncher (Fig. 29), used extensively in New Jersey, is so arranged that the arms may be adjusted to any size bunch desired by simply loosening the bolts at either end, and pulling out the arms so as to fit the shape of the bunch, and thus both ends can be bunched properly. The style of buncher and knives in favor with growers in the famous asparagus region near Concord, Mass., are seen in Fig. 30, and the process of bunching in Fig. 31. Tying materials.--Twine, Cuban bast, sisal, and various other materials are used for tying, but nothing is better for this purpose than raffia fiber. This is obtained from the raffia or rofia palm, a native of the island of Madagascar. The tree sends enormous branches from near the ground, the pinnate leaves of which produce this fiber. One palm frond will produce eighty to one hundred long, green leaflets from two to five feet in length, and from this the fiber is prepared. "Silk lamba" is also a product of this palm. Raffia fiber is now extensively used for tying up plants, for grafting, and many other purposes, as it is very strong, as soft as silk, and is not affected by moisture or changes of temperature, and it does not break or ravel when folded or knotted. Rubber bands.--The use of rubber bands for fastening asparagus bunches has recently been found to have some advantages not possessed by other materials. Prof. W. J. Green, of the Ohio Experiment Station, writes in Bulletin No. 9: "The work can be done more rapidly and better. The saving in time is fully one-third, which will pay for the increased cost of rubber over string, reckoning wages at seventy-five cents per day. This difference might be less where expert tyers are employed, or very low rates per hundred bunches are paid. In any case, the work can be done in a manner that is much more satisfactory to dealers with rubber than with string. This is owing to the fact that rubber holds the bunches intact, while string allows them to fall apart and to become unsightly. Doubtless, in some cases, dealers would be willing to pay more for bunches fastened with rubber than for those put up in the ordinary manner. Even though no difference is made in price for asparagus put up by the two methods, the bunches fastened with rubber bands sell more readily than those tied with string. "Rubber bands can be bought for two dollars per pound, and the size best adapted to the purpose run about two thousand bands per pound, or sufficient for one thousand bunches. This makes rubber bands cost about two cents per dozen bunches more than string, if the saving in labor is not taken into consideration. "The saving in the item of labor depends, of course, upon the kind of labor employed. In determining the relative value of the two methods not only must cost of labor be taken into consideration, but the character of the market as well. When competition is not strong careful bunching is not a matter of great importance, but in many markets it is essential that the bunches be put up in such a manner that they will not fall apart. In such cases rubber bands will more than pay for their extra cost, by insuring more ready sales, if not by increasing the price. "The method employed in bunching with rubber bands is to slip a band over an ordinary teacup--one with straight sides and without a handle; fill the cup with asparagus shoots, the heads downward, and then slip the band from the cup to the bunch. This makes a bunch of about the right size, and gives the upper end a nicely rounded appearance. All that remains to be done is to slip on another band and to square the butts with a sharp knife. Possibly a metallic cup would answer better, being thinner, but a teacup is not objectionable in this particular. If smaller bunches are desired than the smallest cup that can be found, it is not necessary to fill the cup."

Previous: Cutting
Next: Marketing

SHARE

ADD TO EBOOK